Utilization Of Buton Asphalt Solid Waste (ASW) Waste Bitumen Extraction In Concrete

Siti Aja Aulia, Januarti Jaya Ekaputri

Abstract


Indonesia has 650 million tons of Buton Rock Asphalt (Asbuton) deposits.  The mineral residue, known as Asphalt Solid Waste (ASW). The extraction left ASW by 65-90% of asbuton’s weight. However, 770 thousand tons/year of ASW remain underutilized, causing environmental pollution due to its hydrocarbon content. Based on XRD results, Asbuton minerals were dominated with 46% CaCO3, which are potential as a subtitute material in concrete. However, its hydrocarbon content at 68,911 ppm raises concerns. To prevent ASW hydrocarbons from contaminating concrete, solidification was attempted. This study investigates solidification by making Artificial Coarse Aggregate (ACA) products and using ASW as a subtitute for gravel in concrete. The ACAs were produced from a mixture of ASW and cement, molded into 50 x 100 mm cylinders, crushed after twenty eight-days moist curing, and tested according to ASTM C33 standard of gravel. ASW replaced 0-12.5% by volume of sand and ACA replaced 0-12.5% by volume of gravel in concrete with a target compressive strength of 45 MPa at twenty eight-days. Heat of hydration and shrinkage were tested to indentify the impact of CaCO3 from ASW on concrete. The results showed that ACA could reduce 9% of ASW hydrocarbons. However, the ACA produced did not meet the gravel standard in ASTM because ACA absorption reached 6.75% and abrasion test up to 57%. Neverthless, ASW’s high absorption reduced heat hydration by 10% and shrinkage by 83% compared to normal concrete.

Keywords


Asphalt Solid Waste; Hydrocarbon; Artificial Aggregate; Green Concrete; Internal Curing Effect

References


Arisat., and Hendrajaya, L. (2016, 21 Mei). Fisika Pengolahan Aspal Buton. Seminar Nasional Pendidikan dan Saintek (SNPBS). Universitas Muhammadiyah Surakarta, Surakarta. ISSN: 2557-533X

Imaduddin, D., & Amal, R.M. (2020). Skripsi TK184704: Studi Pemisahan Bitumen dari Asbuton Menggunakan Proses Milling dengan Penambahan Solar, Surfaktan Sodium Dedocyl Benzenesulfonat (SDBS) Dan Natrium Hidroksida (NAOH). FTIRS Institut Teknologi Sepuluh Nopember.

Halimi, M., Mochtar, I. B., & Altway, A. (2014). A Breakthrough in Asphalt Tech-nology-Cheaper Bitumen Extracted from “Asbuton”, the Rock Asphalt of Buton Island, Indonesia. International Journal of Education and Research, Vol. 2, Pp. 347-358. ISSN: 2201-6740

Saadah, N., Altway, A., & Rachmawati, Y. (2020). Catalytic Pyrolysis of Asbuton into Liquid Fuel with Zeolite as Catalyst. Malaysian Journal of Fundamental and Applied Science, Vol. 16, Pp. 196-200. https://doi.org/10.11113/mjfas.v16n2.1548

CNBC Indonesia. (2021, 21 Februari). Wika Bitumen Targetkan Produksi Asbuton 500 Ribu Ton/Tahun. https://www.cnbcindonesia.com/market/20210218172559-19-224423/wika-bitumen-targetkan-produksi-asbuton-500-ribu-ton-tahun

Ezeokpube, G.C., Alaneme, G.U., Attah, I.C., Udousoro, I.M., & Nwogbo, D. (2022). Experimental Investigation of Crude Oil Contaminated Soil for Sustainable Concrete Production. Architecture, Structures and Construction, Vol.2, Pp. 349-364 https://doi.org/10.1007/s44150-022-00069-2.

Shahrabadi, H., & Vafaei, D. (2015). Effect of Kerosene Impacted Sand on Compressive Strength of Concrete in Different Exposure Conditions. Journal of Materials and Environmental Science, Vol.6, Pp 2665-2672 ISSN : 2028-2508

Abousnina, R., Manalo, A., Lokuge, W., & Al-Jabri, K.S. (2018). Properties and Structural Behavior of Concrete Containing Fine Sand Contaminated with Light Crude Oil. Construction and Building Materials, Vol. 189, Pp 1214-1231 https://doi.org/10.1016/j.conbuildmat.2018.09.089.

Departemen Pekerjaan Umum Direktorat Jenderal Bina Marga. (2006). Buku 1 Umum Pemasandatan Asbuton No: 001 – 01 / BM / 2006. Bina Marga, Jakarta.

Li, W., Wang, X. C., Xiong, L., & Huang, Z. (2020, 10-12 Juli). Experimental Study on the Dry Shrinkage Properties of Nano Concrete Materials. Journal of Physics: Conference Series. IOP Publishing Ltd, Hangzhou. https://doi.org/10.1088/1742-6596/1605/1/012157

Jiang, Y., Ling, T. C., & Shi, M. (2020). Strength Enhancement of Artificial Aggregate Prepared with Waste Concrete Powder and its Impact on Concrete Properties. Journal of Cleaner Production, Vol. 257, Pp.1-9 https://doi.org/10.1016/j.jclepro.2020.120515

Abbas, Z. K, I. (2017). Effect of Kerosene and Gas Oil Products on Different Types of Concrete. International Journal of Science and Research, Vol. 6, Pp.1718-1722, doi: 10.21275/ART20178987

Ahmad, S., Al-Amoudi, O.S.B., Mustafa, Y.M.H., Maslehuddin, M., & Al-Malack, M., (2020). Stabilization and Solidification of Oil-Contaminated Sandy Soil Using Portland Cement and Supplementary Cementitious Materials. Journal of Materials in Civil Engineering ASCE Library, Vol. 32, Pp. 1-13 DOI: 10.1061/(ASCE)MT.1943-5533.0003169

Masrullita, Burhan, R.Y.P., & Trihadiningrum, Y. (2018). Stabilization/Solidification of Waste Containing Heavy Metals and Hydrocarbons Using OPC and Land Trass Cement. Journal of Ecological Engineering, Vol. 19, Pp.88-96 https://doi.org/10.12911/22998993/92926

Roslee, N.F., Kamil, N.A.F.M., Kadir, A.B., Jalil, A.R., Hamzah, N., Noor, N.M., Sandu, A.V. (2022). New Ray on Remediation of High Rings Polycyclic Aromatic Hydrocarbons: Remediation of Raw Petroleum Sludge Using Solidification and Stabilization Method. Archives of Metallurgy and Materials, Vol. 67, Pp. 1201-1208 DOI: https://doi.org/10.24425/amm.2022.141043.

Peraturan Pemerintah Republik Indonesia Nomor 22 Tahun 2021. Tentang Penyelenggaraan Perlindungan dan Pengelolaan Lingkungan Hidup.

Peraturan Pemerintah Republik Indonesia Nomor 101 Tahun 2014. Tentang Pengel-olaan Limbah Bahan Berbahaya Dan Beracun.

Keputusan Menteri Lingkungan Hidup No. 128 Tahun 2003. Tentang Tata Cara Per-syaratan Teknis Pengolahan Limbah Minyak Bumi dan Tanah Terkontaminasi Oleh Minyak Bumi Secara Biologi.

Standar Nasional Indonesia Nomor 7064 Tahun 2014. Tentang Semen portland komposit.

American Society for Testing and Material (ASTM) C1602. Standard Specification for Mixing Water Used in the Production of Hydraulic Cement Concrete.

American Society for Testing and Material (ASTM) C33. Standard Specification for Concrete Aggregates.

American Concrete Institute (ACI) 116. Cement and Concrete Terminology.

American Society for Testing and Material (ASTM) C230. Standard Specification for Flow Table for Use in Tests of Hydraulic Cement

American Concrete Institute (ACI) 211.4R. Guide for Selecting Proportions for High-Strength Concrete Using Portland Cement and Other Cementitious Materials.

“Cement and Concrete Terminology ACI 116R-00.”

Chusilp, N., Jaturapitakkul, C., & Kiattikomol, K. (2009). Effects Of LOI of Ground Bagasse Ash on the Compressive Strength and Sulfate Resistance of Mortars. Construction and Building Materials, 23, 3523–3531. https://doi.org/10.1016/j.conbuildmat.2009.06.046

Atis, C.D. (2005). Strength Properties of High-Volume Fly Ash Roller Compacted and Workable Concrete, and Influence of Curing Condition. Cement and Concrete Research, Vol. 35, Pp. 1-10 doi:10.1016/j.cemconres.2004.07.037.

Abdel-Gawwad, H.A., Heikal, M., Mohammed, M.S., El-Aleem, S.A., Hassan, H.S., Vásquez García, S.R., & Rashad, A.M. (2019). Evaluating the Impact of Nano-Magnesium Calcite Waste on the Performance of Cement Mortar in Normal and Sulfate-Rich Media. Construction and Building Materials, Vol. 203, Pp.1 https://doi.org/10.1016/j.conbuildmat.2019.01.108.

Syamsunur, D., Wei, L., Ahmed Memon, Z., Surol, S., & Md Yusoff, N. I. (2022). Concrete Performance Attenuation of Mix Nano-SiO2 and Nano-CaCO3 under High Temperature: A Comprehensive Review. Materials MDPI, Vol. 15, Pp. 1-24. https://doi.org/10.3390/ma15207073.

Aitcin, P.-C., & Flatt, R. J. (2016). Science and Technology of Concrete Admixtures. Elsevier, British

Hamdi, F., Lapian, F.E.P., Tumpu, M., Irianto, M., Mabui, D.S.S, Raidyarto, A., Sila, A.A., Masdiana., Rangan, P.R., & Hamkah. (2021). Teknologi Beton. Tohar Media, Makassar

Nurrizki, Y. (2022). Tesis RC185401: Pengaruh Removal Untuk Peningkatan Kualitas Low-Grade Fly Ash Pada Aplikasinya di Beton Hijau. FTSPK Institut Teknologi Sepuluh Nopember.

Wu. Z, Khayat. K.H, Shi.C, Tutikian. B. F, Chen. Q. (2021). Mechanisms Underlying the Strength Enhancement of UHPC Modified with Nano-SiO2 and Nano-CaCO3. Cement and Concrete Composites, 119, Pp. 1-14. https://doi.org/10.1016/j.cemconcomp.2021.103992

Fu, Q., Zhang, Z., Zhao, X., Xu, W., & Niu, D. (2022). Effect Of Nano Calcium Carbonate on Hydration Characteristics and Microstructure of Cement-Based Materials: A Review. Journal of Building Engineering, Vol. 50, Pp.1-17. https://doi.org/10.1016/j.jobe.2022.104220.




DOI: http://dx.doi.org/10.30659/jacee.7.1.%25p

Refbacks

  • There are currently no refbacks.


JACEE (Journal of Advanced Civil and Environmental Engineering)
is published by Fakultas Teknik Universitas Islam Sultan Agung, Indonesia, in collaboration with Federation Internationale du Beton (fib).
Jl. Raya Kaligawe Km.4, PO BOX 1054/SM Semarang 50112
Website: https://ft.unissula.ac.id/
Email: jacee@unissula.ac.id

ISSN: 2599-3356 (Online)
DOI : 10.30659/jacee

This work is licensed under a Creative Commons Attribution 4.0 International License

Get a feed by atom here, RSS2 here and OAI Links here